CuZnAl催化剂甲醇水蒸气重整制氢催化性能研究

石油炼制与化工 ›› 2013, Vol. 44 ›› Issue (10): 23-27.

CuZnAl催化剂甲醇水蒸气重整制氢催化性能研究

张文斌¹,梅华¹,陈晓蓉¹,周文²

1. 南京工业大学化学化工学院
2. 防化研究院

收稿日期:2013-02-04 修回日期:2013-03-13 出版日期:2013-10-12 发布日期:2013-09-22
通讯作者: 梅华 E-mail:meihua@njut.edu.cn
基金资助:
江苏省科技厅产学研前瞻项目

HYDROGEN PRODUCTION FROM METHANOL STEAM REFORMING OVER CuZnAl CATALYSTS

Received:2013-02-04 Revised:2013-03-13 Online:2013-10-12 Published:2013-09-22

摘要/Abstract

摘要： 采用共沉淀法制备一系列CuZn和CuZnAl催化剂，考察了催化剂对甲醇水蒸气重整制氢反应的催化性能，并采用BET，XRD，H2-TPR等对催化剂进行表征，以探讨Al和Cu/Zn比对催化剂活性的影响。在合适的Cu/Zn比时，引入Al能提高催化剂的比表面积和活性组分的分散度，以及稳定表面活性物种。对比试验结果表明：在所考察的CuZnAl催化剂中，Cu50Zn40Al10催化剂对甲醇水蒸气重整反应的催化活性最高，在温度250 ℃、压力1 MPa、 n（H2O）/n（CH3OH） = 1.5、体积空速为0.56 h-1的条件下，甲醇转化率达到100%，氢气产率达到 97.7%；经过200 h连续实验，Cu50Zn40Al10催化剂上甲醇蒸汽重整反应的转化率稳定在97%左右，其稳定性明显优越于Cu50Zn40催化剂。

Abstract: A series of CuZn and CuZnAl catalysts were prepared by co-precipitation method. The catalytic performance of these catalysts for methanol steam reforming was investigated. The catalysts were characterized by BET, XRD, H2-TPR and N2O chemisorptions to explore the effect of the introduction of Al into CuZn catalyst. The results show that with the moderate ratio of Cu/Zn, the addition of Al can enlarge the specific surface area of CuZn catalyst and promote the dispersion and stability of Cu species on the catalyst surface and that the Cu50Zn40Al10 catalyst exhibits the highest catalytic activity for methanol steam reforming in the tested CuZnAl catalysts. The methanol conversion reaches 100% and the hydrogen yield is up to 97.7% under the reaction conditions: T=250 oC and P=1.0 MPa, H2O/CH3OH=1.5 molar ratio, VHSV=0.56 h-1. The Cu50Zn40Al10 catalyst has the excellent catalytic stability for methanol steam reforming during 200 h on stream and the methanol conversion has been kept at around 97%, much better than that of Cu50Zn40.

张文斌梅华陈晓蓉周文. CuZnAl催化剂甲醇水蒸气重整制氢催化性能研究[J]. 石油炼制与化工, 2013, 44(10): 23-27.

参考文献

[1] Agarwal V, Patel S, Pant K K. H2 Production by Steam Reforming of Methanol over Cu/ZnO/Al2O3 Catalysts: Transient Deactivation Kinetics Modeling[J]. Appl Catal A, 2005, 279(1-2):155-164.
[2] Eliezer D, Eliaz N, Senkov O N, et al. Positive Effects of Hydrogen in Metals[J]. Mater Sci Eng A, 2005, 280(1):220-224.
[3] 冯钰.甲醇裂解-变压吸附联合制氢技术的应用[J].化工矿物与加工,2001,6(12):13-14.
[4] 刘京林，孙党莉.甲醇蒸汽转化制氢和二氧化碳技术[J].甲醛与甲醇,2005,2(1):31-33.
[5] 赵明正.甲醇裂解制氢装置的运用[J].石油与天然气化工,2003,32(5):278-280.
[6] Chiu K L, Kwong F L. Oxidation States of Cu in the CuO/CeO2/Al2O3 Catalyst in the Methanol Steam Reforming Process[J]. Curr Appl Phys, 2012,12 (4):1195-1198.
[7] Yang Hung Ming, Chan Min Ke. Steam Reforming of Methanol over Copper-yttria Catalyst Supported on Praseodymium-aluminum Mixed Oxides[J]. Catal Commun, 2011,12(15):1389-1395.
[8] Choi Y, Stenger H G. Fuel Cell Grade Hydrogen from Methanol on a Commercial Cu/ZnO/Al2O3 Catalyst[J]. Appl Catal B, 2002,38(4):259-269.
[9] Sanches S G, Huertas Flores J, Avillez R R, et al. In?uence of Preparation Methods and Zr and Y Promoters on Cu/ZnO Catalysts Used for Methanol Steam Reforming[J]. Int J Hydrogen Energy, 2012,37(8):6572-6579.
[10] Kniep B L, Girgsdies F, Ressler T. Effect of Precipitate Aging on the Microstructural Characteristics of Cu/ZnO Catalysts for Methanol Steam Reforming[J], J Catal, 2005,236(1):34-44.
[11] Turco M, Cammarano C, Bagnasco G, et al. Oxidative Methanol Steam Reforming on a Highly Dispersed CuO/CeO2/Al2O3 Catalyst Prepared by a Single-step Method[J]. Appl Catal B, 2009,91(1-2):101-107.
[12] Mierczynski P, Maniecki T P, Chalupka K, et al. Cu/ZnxAlyOz Supported Catalysts (ZnO:Al2O3 = 1,2,4) for Methanol Synthesis[J]. Catal Today, 2011,176(1):21-27.
[13] 余力挺，马建新.CuZnAlZr催化剂上甲醇氧化水蒸气重整制氢催化剂组成的优化[J].催化学报,25(7):523-528.
[14] Lindstrom B, Pettersson L J. Hydrogen Generation by Steam Reforming of Methanol Over Copper-based Catalysts for Fuel Cell Applications[J]. Int J Hydrogen Energy,2001,26(9):923-933.
[15] Agrell J, Birgersson H, Boutonnet M, et al. Production of Hydrogen From Methanol Over Cu/ZnO Catalysts Promoted by ZrO2 and Al2O3[J]. J Catal, 2003,219(2):389-403.
[16] Reppley B A, Amphlett J C, Kearns L M, et al. Methanol-steam Reforming on Cu/ZnO/Al2O3 Part 1: the Reaction Network[J]. Appl Catal A, 1999,179(1):21-29.
[17] Sircar S, Waldron W E, Rao M B, et al. Hydrogen Production by Hybrid SMR-PSA-SSF Membrane System[J]. Sep Purif Technol, 1999,17(1):11-20.
[18] Hinrichsen O, Genger T, Muhler M. Chemisorption of N2O and H2 for The Surface Determination of Copper Catalysts[J]. Chem Eng Technol, 2000,23(1):956-959.