快速溶剂萃取法提取印尼油砂沥青的工艺研究

石油炼制与化工 ›› 2022, Vol. 53 ›› Issue (4): 58-62.

快速溶剂萃取法提取印尼油砂沥青的工艺研究

王智超^1,2,王擎^1,2,柏静儒^1,2,李础安^2,3

1. 东北电力大学能源与动力工程学院
2. 东北电力大学页岩油综合利用教育部工程研究中心 3. 东北电力大学教学质量监控与评价中心

收稿日期:2021-09-02 修回日期:2021-10-14 出版日期:2022-04-12 发布日期:2022-03-29
通讯作者: 李础安 E-mail:20182816@neepu.edu.cn
基金资助:
国家自然科学基金

STUDY ON EXTRACTION TECHNOLOGY OF THE INDONESIAN OIL SANDS BITUMEN BY ACCELERATED SOLVENT EXTRACTION

Received:2021-09-02 Revised:2021-10-14 Online:2022-04-12 Published:2022-03-29

摘要/Abstract

摘要： 采用快速溶剂萃取技术提取油砂沥青，通过单因素试验和正交试验得出加压溶剂萃取技术的最佳工艺参数。研究结果表明：在高压条件下，混合适量硅藻土分散剂，快速溶剂萃取法提取油砂沥青比传统索氏抽提与费舍尔试验更有优势。利用正交试验获得快速溶剂萃取法提取油砂沥青的最佳工艺参数为：压力10 MPa，土砂比（硅藻土与油砂的体积比）2∶1，萃取温度160 ℃，循环次数5次，溶剂选择四氢呋喃，单次静态萃取时间12 min。

关键词: 油砂沥青质, 快速溶剂萃取, 正交试验

Abstract: Accelerated solvent extraction technology was used to extract oil sands bitumen, and the optimum technological parameters of pressurized solvent extraction technology were obtained by single factor test and orthogonal test. The results show that the accelerated solvent extraction method is superior to the traditional Soxhlet extraction and Fisher test in the pressure condition and the mixture of diatomite dispersant. The optimal process parameters of accelerated solvent extraction for the extraction of oil sands bitumen were obtained by orthogonal test as follows: a pressureof 10 MPa, a soil-sand volume ratio of 2:1, a extraction temperature of 160 ℃ , a times of cycles of 5 , solvent tetrahydrofuran, and a single static extraction time of 12 min.

Key words: oil sands bitumen, accelerated solvent extraction, orthogonal experiment

王智超王擎柏静儒李础安. 快速溶剂萃取法提取印尼油砂沥青的工艺研究[J]. 石油炼制与化工, 2022, 53(4): 58-62.

参考文献

[1]王艺，刘洋，黄慧杰.汽油罐内收发油流动模拟研究[J].东北电力大学学报, 2021, 41(1):65-75 [2]可存峰，广萌萌，张亚宁，李炳熙.生物质微波热化学转化技术[J].东北电力大学学报, 2021, 41(3):1-9 [3] Wang J, Feng L, Steve M, Tang X, Gail TE, Mikael H.China' s unconventional oil: A review of its resources and outlook for long-term production[J] . [J].Energy, 2015, 82:31-42 [4]侯明扬.年全球油气资源并购市场特点及前景展望[J].国际石油经济, 2021, 29(3):45-52 [5]王擎，高瑞萌，贾春霞，王智超.低温干馏过程中油砂沥青化学结构变化的研究[J].东北电力大学学报, 2018, 38(1):57-65 [6]王擎，王智超，贾春霞，宫国玺.基于固体核磁共振技术对油砂沥青质结构的研究[J].化工进展, 2014, 33(6):1392-1396 [7]Vilcáez J.Watanabe M， Watanabe N.， Kishita A.， Adschiri T.. Hydrothermal extractive upgrading of bitumen without coke formation[J].Fuel, 2012, 102(1):379-385 [8]Schramm L，Morrison C，Stasiuk E.N.. Some effects of chemical additions to nascent primary froth from the hot water flotation of bitumen from Athabasca oil sand[J].Fuel Process Technology, 1998, 56(3):243-261 [9]冯杰, 李鑫钢, 许宁津, 隋红.有机溶剂萃取加拿大油砂应用研究[J].化学工业与工程, 2015, 32(1):11-16 [10]徐庆虎，崔德春，纪钦洪，熊亮，于广欣，刘强.溶剂对油砂沥青改质溶剂脱沥青影响研究[J].炼油技术与工程, 2021, 51(3):9-12 [11]王擎，王智超，贾春霞，宫国玺.采用-和研究印尼油砂热解产油过程[J].石油学报石油加工, 2015, 31(4):1003-1008 [12] Z Wang，Q Wang，S Pan, C Jia, J Bai, D Cui.The Chemical Structure and Thermal Evolution of Oil Sands Bitumen: Experimental and Molecular Simulation Study [J].[J]. Journal of Analytical and Applied Pyrolysis, 2021, 158:105271- [13] Z Wang，Q Wang， C Jia. Structural changes in oil sand bitumen during pyrolysis [J][J].J Therm Anal Calorim,, 2017, 127:2215-2223 [14]刘金河，刘银东，李成杰，杨行，杨普江，张庆轩.不同有机溶剂对新疆油砂沥青的组成性质影响[J].化工进展, 2019, 38(12):5525-5531 [15]张坚强，李鑫钢，隋红.离子液体促进溶剂萃取油砂沥青[J].化工进展, 2014, 33(08):1986-1991 [16] J. Liu，X. Cui，J. Huang，L. Xie，X. Tan，Q. Liu..Understanding the stabilization mechanism of bitumen-coated fine solids in organic media from non-aqueous extraction of oil sands [J]. [J].Fuel, 2019, 242:255-264 [17]A. Hooshiar，PUhlik，Q. Liu，T.H. Etsell，D.G. Ivey. .Clay minerals in nonaqueous extraction of bitumen from Alberta oil sands-Part 1. Nonaqueous extraction procedure[J].Fuel Processing Technology, 2012, 94(1):80-85 [18] C. Zheng，M.M. Zhu，R. Zareie，D.K. Zhang. .Characterisation of subfractions of asphaltenes extracted from an oil sand using NMR, DEPT and MALDI-TOF [J][J].Journal of Petroleum Science and Engineering, 2018, 168:148-155 [19] 龚迎莉，汪双清，孙玮琳，沈斌.烃源岩氯仿沥青的加速溶剂萃取和传统萃取方法的对比[J]. [J].分析仪器, 2012, (6):77-81 [20] 孟建华，魏彩云，王汇形，王慧.快速溶剂抽提仪萃取岩石中氯仿沥青_A_方法探索[J].[J].现代科学仪器, 2009, (2):96-98 [21]吕洪滨，郗丽娟，孙乐阳，白瑞.硅藻土负载固体超强酸多相类芬顿降解罗丹明[J].东北电力大学学报, 2019, 39(4):49-53