电感耦合等离子体质谱仪测定生物柴油中微量元素的微波消解工艺研究

›› 2018, Vol. 49 ›› Issue (6): 96-100.

• 分析与评定 • 上一篇

电感耦合等离子体质谱仪测定生物柴油中微量元素的微波消解工艺研究

和莉,谢晓岚,肖娟,曹开科

青海省有色地质测试中心

收稿日期:2017-11-14 修回日期:2017-12-08 出版日期:2018-06-12 发布日期:2018-06-20
通讯作者: 和莉 E-mail:smileli999@126.com
作者简介:2018-06-15
基金资助:
青海省有色地质测试中心创新项目

STUDY ON MICROWAVE-ASSISTED DIGESTION OF BIODIESEL FOR DETERMINATION OF TRACE ELEMENTS BY ICP-MS

Received:2017-11-14 Revised:2017-12-08 Online:2018-06-12 Published:2018-06-20

摘要/Abstract

摘要： 采用稀硝酸和过氧化氢溶液对生物柴油进行微波消解，并利用电感耦合等离子体质谱仪（ICP-MS）对消解后的生物柴油进行微量元素测定，研究硝酸浓度和过氧化氢添加量对生物柴油消解效果的影响，并综合剩余碳含量和剩余酸度作为评价指标。结果表明：当采用6.0 mL浓度为6.0 mol/L的硝酸和2.5 mL过氧化氢的混合溶液对0.6 g生物柴油进行微波消解后，剩余碳含量和剩余酸度分别为5.3%和6.4%；ICP-MS测定Ba，Mn，Mo，Cr，Cu，Ni，Pb，Sr，V，Zn等分析物的加标回收率为94.2%~107.4%，相对标准偏差小于4.33%。

关键词: 电感耦合等离子体质谱仪, 微波消解, 稀硝酸, 生物柴油 , 微量元素测定

Abstract: A microwave-assisted digestion using diluted nitric acid and hydrogen peroxide as auxiliary agent was explored to determine trace elements in biodiesel by inductively coupled plasma mass spectrometry (ICP-MS). The effect of nitric acid concentration and volume of hydrogen peroxide on biodiesel digestion was investigated, using residual carbon content and residual acidity in final solutions as evaluation index. Results showed that 0.6 g of biodiesel was almost completely digested under the optimal conditions: 6 mL nitric acid (6 mol/L) and 2.5 mL hydrogen peroxide. The residual carbon content and the residual acidity in digests were lower than 5.3% and 6.4%, respectively. After sample digested, Ba, Cr, Cu, Mn, Mo, Ni, Pb, Sr, V and Zn were determined by ICP-MS and the recovery rate was in the range of 94.2% to 107.4%. All RSDs were less than 4.33%.

Key words: ICP-MS, microwave-assisted digestion, diluted nitric acid, biodiesel, Trace elements determination

和莉谢晓岚肖娟曹开科. 电感耦合等离子体质谱仪测定生物柴油中微量元素的微波消解工艺研究[J]. , 2018, 49(6): 96-100.

参考文献

[1] 裴永浩, 于万舒, 吴桐, 等. 我国生物燃料的现状及展望[J]. 现货化工, 2016, 7(36): 1-4 [2] 邹瑜, 刘勇军, 李志峰, 等. 制备生物柴油负载型固体催化剂的研究进展[J]. 化工新型材料，2015,43(1):27-29 [3] Jain S, Sharma MP. Effect of metal contents on oxidation stability of biodiesel/diesel blends[J]. Fuel, 2014,116:14–8. [4] 吴江, 陈波水, 方建华等. 生物柴油发动机磨损特性实验研究[J]. 石油炼制与化工, 2017, 48(4): 73-77 [5] 石晓燕, 贺克斌, 谭吉华. 生物柴油对柴油机排放和人类健康的影响[J]. 化工环保, 2009, 29( 3) : 220—225 [6] Wang YF, Huang KL, Li CT, et al. Emissions of fuel metals content from a diesel vehicle engine[J]. Atmos Environ, 2003, 37:4637–43. [7] 尤可为, 葛蕴珊, 何超, 等.柴油机燃用生物柴油的非常规污染物排放特性[J]. 内燃机学报, 2010, 28(6) : 506—509 [8] 刘金胜, 蔺建民, 张建荣等. 生物柴油氧化安定性及氧化反应表观活化能的研究[J]. 石油炼制与化工, 2013, 44(2): 22-26. [9] Annual Book of ASTM Standards, ASTMD6751-15c. Standard specification forbiodiesel fuel blend stock (B100) for middle distillate fuels[S]. In: ASTM International, 2015 [10] BS EN 14538. Fat and oil derivatives – Fatty Acid Methyl Esters (FAME) –Determination of Ca, K, Mg and Na content by optical emission spectral analysis with inductively coupled plasma (ICP OES)[S]. In: European Standards, 2006 [11] Wiltsche H, Winkler M, Tirk P. Matrix effects of carbon and bromine in inductively coupled plasma optical emission spectrometry[J].J Anal At Spectrom,2015, 30:2223–34 [12] Sanchez R, Sanchez C, Lienemann C-P, et al. Meta land metal loid determination in biodiesel and bioethanol[J]. J Anal At Spectrom,2015, 30:64–101 [13] Müller E I, Mesko M F, Moraes D P, et al. Wet digestion using microwave heating. In: Flores EMM, editor. Microwave-assisted samplepreparation for trace element analysis[C]. Amsterdam: Elsevier, 2014 [14] Stewart I I, Olesik J W. The effect of nitric acid concentration and nebulizer gas flow rates on aerosol properties and transport rates in inductively coupled plasma sample introduction[J]. J Anal At Spectrom, 1998, 13:1249–56 [15] Stewart I I, Olesik J W. Steady state acid effects in ICP-MS[J]. J Anal At Spectrom,1998, 13:1313–20. [16] Bizzi C A, Flores E L M, Nóbrega J A, et al. Evaluation of a digestion procedure based on the use of diluted nitric acid solutions and H2O2 for the multi element determination of whole milk powder and bovine liver by ICP-based techniques[J]. J Anal At Spectrom, 2014, 29:332–338. [17] 刘何沛, 褚小立, 郑煜等. 紫外荧光法测定轻质油品中总硫含量的影响因素[J]. 石油炼制与化工, 2017, 48(9) :97-102 [18] 靳福全. Li-Ca-Zn-Al-O催化油脂醇解反应[J]. 石油炼制与化工, 2016, 47(10) :17-22

电感耦合等离子体质谱仪测定生物柴油中微量元素的微波消解工艺研究

STUDY ON MICROWAVE-ASSISTED DIGESTION OF BIODIESEL FOR DETERMINATION OF TRACE ELEMENTS BY ICP-MS

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	李小刚雷爱莲苏辉张遂心张大华. 生物柴油对发动机油抗氧化性能的影响[J]. 石油炼制与化工, 2023, 54(1): 123-127.
[2]	夏鑫蔺建民李妍陶志平. 生物柴油制脂肪酸单甘油酯及其抗磨性能研究[J]. 石油炼制与化工, 2022, 53(9): 89-95.
[3]	赖婷婷戴新刘雅琼王轲吴梅曾双亲. 微波消解/ICP-AES法测定拟薄水铝石中的微量Na和S元素[J]. 石油炼制与化工, 2022, 53(7): 86-91.
[4]	邵腾飞包冬梅杨超. 添加剂对含生物柴油的发动机油抗氧化性能的影响[J]. 石油炼制与化工, 2021, 52(8): 90-95.
[5]	赵文慧王轲冒昕烨戴新高萍. 电感耦合等离子体原子发射光谱法测定催化裂化烟气硫转移剂中铈含量[J]. 石油炼制与化工, 2020, 51(3): 85-88.
[6]	荣丽丽张树全邓旭亮张岩孙玲. 微波消解-电感耦合等离子体原子发射光谱法法测定一氧化碳助燃剂中贵金属含量[J]. 石油炼制与化工, 2019, 50(4): 78-82.
[7]	王海京杜泽学高国强. 近/超临界醇解制备生物柴油的研究[J]. 石油炼制与化工, 2017, 48(6): 35-38.
[8]	李传亮计伟荣马兵兵方雨豪. 介孔碳基固体酸的制备及在生物柴油生产中的应用[J]. 石油炼制与化工, 2017, 48(4): 73-77.
[9]	张庆英杜泽学. SRCA生物柴油技术的工业应用[J]. 石油炼制与化工, 2017, 48(1): 22-25.
[10]	侯凯丽,李会鹏. KOH/SBA-15催化大豆油酯交换反应制备生物柴油[J]. 石油炼制与化工, 2011, 42(8): 43-46.
[11]	曹志广1 ,杜泽学2 ,闵恩泽2 . 油脂酯交换制备生物柴油的反应分离耦合工艺[J]. 石油炼制与化工, 2011, 42(10): 1-4.
[12]	秦敏;陈国需;许世海 . 橡胶籽生物柴油氧化安定性及改性研究[J]. 石油炼制与化工, 2010, 41(2): 54-58.
[13]	陈立功,周星,杨鑫. 均相碱催化高动物油含量餐饮废油制备生物柴油[J]. 石油炼制与化工, 2010, 41(12): 52-55.
[14]	黄永茂袁金磊杨学林李小云. 用于棉籽油制备生物柴油的固体酸催化剂研究[J]. 石油炼制与化工, 2009, 40(8): 31-35.
[15]	余济伟任立国张晓丽高文艺. 新型碳基固体酸催化剂在酯化反应中的催化性能研究[J]. 石油炼制与化工, 2009, 40(5): 38-42.